葛向东,高强,路阳,杨雷,安中彦.风扇转子动特性试验与分析[J].航空发动机,2020,46(2):66-70
风扇转子动特性试验与分析
Test and Analysis of Dynamic Characteristic of Fan Rotor
  
DOI:
中文关键词:  风扇转子  不平衡量  动特性  三圆法  弹性线  相位  航空发动机
英文关键词:fan rotor  values of unbalance  dynamic characteristic  three circles method  elasticity line  phase  aeroengine
基金项目:国防科技重点工程项目资助
作者单位E-mail
葛向东,高强,路阳,杨雷,安中彦 中国航发沈阳发动机研究所沈阳110015 usa29569721@126.com 
摘要点击次数: 1379
全文下载次数: 887
中文摘要:
      转子不平衡是引起发动机振动的主要原因。针对风扇转子工艺状态平衡良好,但工作状态不平衡量较大所引起振动偏 大的现象,对其变化规律及影响因素开展转子动特性试验。采用卧式转子试验器测量风扇转子在工作转速范围内各截面的振动响 应,利用三圆法测算出转子动不平衡量在高、低转速间存在的明显差异,主要是套齿连接结构刚度变化及叶片工作状态差异引起。 通过窄带跟踪滤波提取出转子在各典型转速下基波弹性线,发现风扇转子本身未发生较大挠曲变形,为准刚体状态。其相位测试结 果表明:风扇转子与多功能轴间存在明显的非同步振动规律。
英文摘要:
      Unbalanced rotor was the main cause of engine vibration. In view of the phenomenon that the process state of the fan rotor was well balanced,but the vibration caused by the large amount of unbalanced working state was large,the dynamic characteristic test of the rotor was carried out for the variation law and influencing factors. A horizontal rotor tester was used to measure the vibration response of each section of the fan rotor in the working speed range. The three circles method was calculated by obvious difference between the rotor dynamic unbalance values at high and low rotational speed,which was mainly caused by the change of the structural stiffness of the socket connection and the difference of the blade working state. The fundamental elastic line of rotor at each typical rotational speed was extracted by narrow-band tracking filter. It was found that no large flexure deformation occur in the fan rotor itself,the fan rotor was quasi-rigid state. The phase test results show that there is obvious non-synchronous vibration law between the fan rotor and the multi-function shaft.
查看全文  查看/发表评论  下载PDF阅读器